Before any troubleshooting is done, make sure to prepare safely for the job by doing the following:
- Turn off power to an electric water heater system. Do this by turning off the circuit breaker or fuse powering the heater.
- Turn the gas pilot control valve to “pilot” setting.
- Shut off the water supply to the water heater.
Let’s take a look at each problem and what possible causes and repairs exist.
No Hot Water Flow
Possible Causes
- Faulty gas pilot
- Faulty gas thermocouple
- Faulty gas pilot control valve
Possible Repairs
- Check that the gas pilot flame and pilot is operational.
- Re-tighten, reposition or replace the gas thermocouple.
- Replace the gas pilot control valve.
Insufficient Hot Water
Possible Causes
- Hot water system is undersized for water heating demands
- Broken or damaged dip tube allowing cold and hot water to mix in the tank.
- Faulty plumbing installation has crossed cold and hot water connections
- Gas supply or control problems
Possible Repairs
- Make sure the hot water system is not being overtaxed by hot water supply demands. The hot water system should have 75% of its capacity as hot water (e.g., a 40 gallon WH should be used for a demand of 30 gallons).
- Undo the cold-water inlet and pipe nipple and remove dip tube. Check the condition and replace if required.
- Check for crossed connection by turning off the water supply to the hot water system. Open a hot water faucet. If there is water flow, then there is a crossed connection somewhere. Check for a hot water line connected to a cold-water connection on the water heater or appliances such as washer, dishwasher, faucet or shower valves.
- Check for a proper flame from the burner. A natural gas flame should be bright blue with the tip of the flame having just a tinge of yellow. A propane flame should have a bluish green flame with a tinge of yellow at the tip.
Rust Colored Water
Possible Causes
- Corrosion occurring inside glass lined tank
- Sacrificial anode rod is failing (anode rods dissolve slowly to prevent rusting in the tank)
Possible Repairs
- Replace the sacrificial anode rod with magnesium anode rod. Anode rods are available from a plumbing supply house.
Rotten Egg Smell
Possible Causes
- Bacteria in the tank sediment fed from hydrogen gas created from decay of sacrificial anode.
Possible Repairs
- Flush the hot water system using a hydrogen peroxide solution of 2 pints 3% peroxide to 40 gallons of water, treat tank and run some of the solution into water lines.
- Let peroxide solution set in the tank and pipes for 2 hours. The Solution is not toxic and requires no rinsing.
- If the problem persists, replace the anode with a zinc-alloy anode.
- If the problem still remains, replace the hot water system with a plastic lined tank type.
Low Rumbling or Popping Noise
Possible Causes
- Noise heard is the sound of boiling water. Excessive buildup of sediment in bottom of the tank is causing overheating of the tank bottom and boiling of water to occur.
Possible Repairs
Remove sediment by flushing the hot water system
Water Leak Around Base of Heater
Possible Causes
- A faulty T&P (temperature and pressure) relief valve
- The T&P valve leaks due to excessive pressure, overheating or is stuck
- A leak from overhead or nearby plumbing connection
- A leaking water tank (corrosion likely)
Possible Repairs
- Place the bucket under overflow pipe. Open and flush T&P valve clear of debris. If the leak remains from the valve, replace the valve.
- Reduce the thermostat setting to prevent tank overheating and opening T&P relief valve.
- Inspect bottom of the tank by looking through the combustion chamber. If water marks or heavy rusting is noticed or if water is noticed setting in the combustion chamber bottom, then the water heater needs to be replaced.
If you have an issue with a blocked drain brisbane or hot water system brisbane, then you need a 24 hour plumber brisbane or an emergency plumber brisbane to service you. You might also reach out to a gas plumber brisbane to help you. Its important that you have a plumber brisbane or a brisbane Plumber you can trust. A drain camera Brisbane plumber can also be important to you. If you suspect carbon monoxide is present, you will also need Carbon Monoxide Testing Brisbaneor plumbing Brisbane, Plumber Fortitude Valley, Plumber Albion, Plumber Alderley, Plumber Annerley, Plumber Ascot, Plumber Ashgrove, Plumber Aspley, Plumber Auchenflower, Plumber Balmoral, Plumber Banks Creek, Plumber Anstead, Plumber Bald Hills, Plumber Banyo, Plumber Bardon, Plumber Belmont, Plumber Boondall, Plumber Bowen Hills, Plumber Bracken Ridge,Plumber Bridgeman Downs, Plumber Brighton, Plumber Brisbane Airport, Plumber Brisbane City, Plumber Brookfield, Plumber Bulimba, Plumber Carina, Plumber Carseldine,Plumber Chandler, Plumber Chapel Hill, Plumber Chelmer, Plumber Chermside, Plumber Chermside West,Plumber Clayfield, Plumber Coorparoo, Plumber Corinda, Plumber Deagon, Plumber Dutton Park,Plumber Enoggera, Plumber Everton Park, , Plumber East Brisbane, Plumber Ferny Grove,Plumber Fitzgibbon, Plumber Geebung, Plumber Gordon Park, Plumber Graceville, Plumber Grange, Plumber Greenslopes, Plumber Gumdale, Plumber Hamilton, Plumber Hawthorne,Plumber Heathwood, Plumber Hemmant, Plumber Hendra, Plumber Herston, Plumber Highgate Hill, Plumber Holland Park, Plumber Holland Park West, Plumber Inala, Plumber Indooroopilly,Plumber Jamboree Heights, Plumber Jindale, Plumber Kangaroo Point, Plumber Karana Downs,Plumber Karawatha, Plumber Kedron, Plumber Kelvin Grove, Plumber Acacia Ridge, Plumber Algester, Plumber Archerfield, Plumber Burbank, Plumber Calamvale, Plumber Camp Hill, Plumber Cooper Plains, Plumber Cannon Hill, Plumber Carina Heights, Plumber Carindale, Plumber Doolandella, Plumber Drewvale, Plumber Durack, Plumber Eight Mile Plains, Plumber Ellen Grove,Plumber Fairfield, Plumber Forest Lake, Plumber Gaythorne, Plumber Kenmore, Plumber Kuraby,Plumber Larapinta, Plumber Lutwyche, Plumber Lytton, Plumber Logan City, Plumber Macgregor,Plumber Mackenzie, Plumber Manly, Plumber Mansfield, Plumber Middle Park, Plumber Milton,Plumber Moggill, Plumber Moorooka, Plumber Morningside, Plumber Mount Gravatt, Plumber Mt Ommaney, Plumber Murarrie, Plumber Nathan, Plumber New Farm, Plumber Newmarket, Plumber Newstead, Plumber Norman Park, Plumber Northgate, Plumber Nudgee, Plumber Nundah,Plumber Oxley, Plumber Paddington, Plumber Pallara, Plumber Parkinson, Plumber Ransome,Plumber Redhill, Plumber Richlands, Plumber Riverhills, Plumber Robertson, Plumber Rochedale
